{"product_id":"21212798-pump-genuine-volvo-penta","title":"21212798 Pump | Genuine Volvo Penta Part","description":"\u003ch2\u003e\n 🔧 Product Description\n\u003c\/h2\u003e\n\u003cp\u003e\n Genuine belt-driven flexible-impeller seawater pump for later Volvo Penta 3.0GLP petrol marine engines. It replaces pump 3812522 and uses a 1-1\/4 inch inlet, 1 inch outlet and approximately 6-1\/2 inch serpentine pulley.\n\u003c\/p\u003e\n\u003ch2\u003e\n 🚤 Compatibility\n\u003c\/h2\u003e\n\u003cp\u003e\n Typically suits:\n\u003c\/p\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Volvo Penta 3.0GLP-D\n \u003c\/li\u003e\n \u003cli\u003e\n  Volvo Penta 3.0GLP-E\n \u003c\/li\u003e\n \u003cli\u003e\n  Volvo Penta 3.0GLP-J\n \u003c\/li\u003e\n \u003cli\u003e\n  Volvo Penta 3.0GLP-N\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch2\u003e\n ⚙️ Key Features\n\u003c\/h2\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Current replacement for pump 3812522\n \u003c\/li\u003e\n \u003cli\u003e\n  Belt-driven flexible-impeller design\n \u003c\/li\u003e\n \u003cli\u003e\n  1-1\/4 inch inlet and 1 inch outlet\n \u003c\/li\u003e\n \u003cli\u003e\n  Approximately 6-1\/2 inch serpentine pulley\n \u003c\/li\u003e\n \u003cli\u003e\n  Dedicated 3.0GLP cooling-system configuration\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch2\u003e\n 🔌 Function\n\u003c\/h2\u003e\n\u003cp\u003e\n The pump draws raw water through the vessel intake and supplies the engine cooling and wet-exhaust circuits.\n\u003c\/p\u003e\n\u003ch2\u003e\n ⚠️ Common Signs of Failure\n\u003c\/h2\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Reduced or intermittent exhaust-water discharge\n \u003c\/li\u003e\n \u003cli\u003e\n  Missing or permanently set impeller vanes\n \u003c\/li\u003e\n \u003cli\u003e\n  Seawater leakage from the shaft seal\n \u003c\/li\u003e\n \u003cli\u003e\n  Bearing or pulley noise\n \u003c\/li\u003e\n \u003cli\u003e\n  Corroded pump body\n \u003c\/li\u003e\n \u003cli\u003e\n  Pulley wobble or belt misalignment\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch2\u003e\n 🛠️ Service Notes\n\u003c\/h2\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Establish why the old pump failed before the new one goes on — debris, a blocked strainer, a starved supply or a dry run will take out the replacement just as quickly\n \u003c\/li\u003e\n \u003cli\u003e\n  Fit new gaskets, O-rings and seals on the pump's joint faces and drive, with the faces clean, and use only the sealant the workshop manual for your engine specifies\n \u003c\/li\u003e\n \u003cli\u003e\n  Check the drive and the shaft it runs on — coupling, gear, key, belt or drive dog — while access is good, and renew anything doubtful\n \u003c\/li\u003e\n \u003cli\u003e\n  Prime or fill the pump as the manual for your engine directs, bleed the system afterwards, and confirm it is actually delivering before the boat leaves\n \u003c\/li\u003e\n \u003cli\u003e\n  Tighten mounting and cover fasteners evenly to the manual's figures; pump housings distort easily, and a distorted housing either leaks or binds\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch2\u003e\n 🔄 Supersession \u0026amp; Cross Reference\n\u003c\/h2\u003e\n\u003ch3\u003e\n OEM Supersession Chain\n\u003c\/h3\u003e\n\u003cul\u003e\n \u003cli\u003e\n  21212798 → Supersedes 3812522\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch3\u003e\n OEM \/ Related Numbers\n\u003c\/h3\u003e\n\u003cul\u003e\n \u003cli\u003e\n  3812522 earlier number superseded by this part\n \u003c\/li\u003e\n \u003cli\u003e\n  21213664 - Related flexible-impeller reference; verify pump revision\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch3\u003e\n Other-Brand OEM Numbers\n\u003c\/h3\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Poseidon Marine PM3858229 \/ Johnson 09-5000 family - Rebuild-kit references requiring pump configuration confirmation\n \u003c\/li\u003e\n \u003cli\u003e\n  Johnson Pump: 10-13569-14\n \u003c\/li\u003e\n \u003cli\u003e\n  Johnson Pump: 10-13569-04\n \u003c\/li\u003e\n\u003c\/ul\u003e\n\u003ch2\u003e\n 📦 Condition\n\u003c\/h2\u003e\n\u003cul\u003e\n \u003cli\u003e\n  Genuine Volvo Penta part\n \u003c\/li\u003e\n \u003cli\u003e\n  Brand new\n \u003c\/li\u003e\n \u003cli\u003e\n  Supplied in original or equivalent packaging\n \u003c\/li\u003e\n\u003c\/ul\u003e\n","brand":"Volvo Penta","offers":[{"title":"Default Title","offer_id":53381255069988,"sku":"3895081","price":1110.23,"currency_code":"AUD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0994\/8115\/7924\/files\/original_4fc7d048-f00d-455a-aec6-2122ad13df40.png?v=1788056740","url":"https:\/\/www.sawleysautoandmarine.com.au\/products\/21212798-pump-genuine-volvo-penta","provider":"Sawley's Auto and Marine","version":"1.0","type":"link"}