21538975 Fuel Filter | Genuine Volvo Penta Part
21538975 Fuel Filter | Genuine Volvo Penta Part
Couldn't load pickup availability
In stock — Australian warehouse
Typically reaches our store in 2–3 business days
Availability checked daily with Volvo Penta
✓ Authorised Volvo Penta Dealer · Genuine Volvo Penta parts · Ships Australia-wide
🔧 Product Description
A spin-on primary diesel fuel filter and water separator used on selected Volvo Penta TAD5 and TAD8 industrial engines. It removes particulate contamination and separated water before fuel reaches the engine fuel system.
🚤 Compatibility
Typically suits:
- Volvo Penta TAD840GE
- Volvo Penta TAD841-43GE
- Volvo Penta TAD552VE
- Volvo Penta TAD853VE
- Volvo Penta TAD851-53GE
- Volvo Penta TAD880-82GE
- Volvo Penta TAD880-84VE
- Volvo Penta TAD580-83VE
- Volvo Penta TAD570-72VE
- Volvo Penta TAD570-71VE-B
- Volvo Penta TAD550-51VE
- Volvo Penta TAD540-42VE
- Volvo Penta TAD840-43VE
- Volvo Penta TAD850-52VE
- Volvo Penta TAD870-73VE
- Volvo Penta TAD840GE-B
- Volvo Penta TADH880-82GE
- Volvo Penta TADH880-84VE
- Engine Family: TAD, TADH
⚙️ Key Features
- Genuine Volvo Penta primary fuel filter
- Combined fuel filtration and water separation
- Threaded spin-on service element
- Designed for modern common-rail diesel fuel systems
- Replace at the Volvo Penta service interval or after contaminated-fuel exposure
- Engine type: Four- or six-cylinder turbocharged common-rail industrial diesel
🔌 Function
Filters diesel fuel and separates water before the fuel enters the supply pump and high-pressure injection system.
⚠️ Common Signs of Failure
- Restricted fuel flow and power loss
- Hard starting or loss of prime
- Low fuel-pressure diagnostic code
- Water or contamination visible in the separator
- Fuel leakage around the filter seal or drain
🛠️ Service Notes
- Work clean — cap or cover open connections and keep dirt out of the housing, because contamination introduced at a filter change goes straight to the injection equipment
- Where the design allows it, fill the new filter with clean fuel before fitting, and smear the sealing ring with clean fuel rather than grease
- Renew every seal supplied with the filter and tighten to the marking on the filter or the figure in the workshop manual for your engine; over-tightening distorts the seal and causes leaks
- Prime and bleed the system by the procedure for your engine before cranking, then run up and check the sealing faces for weeps
- Drain and inspect any water trap at the same time and note what comes out — water or dark sludge means the tank and pre-filter need attention too
🔄 Supersession & Cross Reference
OEM / Related Numbers
- 21817175 - related Volvo OEM filter reference
- 23958454 - related Volvo OEM filter reference
- 22296415 and 23476569 - related Volvo filter references
Other-Brand OEM Numbers
- Fleetguard FS20112
- Donaldson P553227
- MANN-FILTER WK 11 038 Z
- Baldwin BF1292-O
- Hengst H7091WK20D677
- Bosch: F 026 402 269
- Fleetguard: FS19950
Aftermarket / Verified Equivalents
- SAMPA 035.434
- Febi Bilstein: 170004
📦 Condition
- Genuine Volvo Penta part
- Brand new
- Supplied in original or equivalent packaging
Shipping & Delivery
Shipping & Delivery
Flat-rate shipping Australia-wide — $14.99 per order, no matter how many parts you add. Orders dispatch from our Kadina, South Australia store. Need it urgently or want to collect in person? Call us on 0412 532 984 before ordering.
Returns & Warranty
Returns & Warranty
14-day change-of-mind returns — if it's not right or you ordered the wrong part, send it back within 14 days in new, unused condition for a refund or exchange. Manufacturer warranties apply to new parts. Full details in our Refunds & Returns policy.
Not sure this fits?
Not sure this fits?
Ask us before you buy — we check part numbers and fitment every day. Call 0412 532 984 (Mon–Fri 8.30am–4.30pm) or message us through the contact page with your engine or vehicle details.
Share
