22463591 Water Pipe | Genuine Volvo Penta Part

🔧 Product Description

Genuine Volvo Penta water pipe, part number 22463591, listed in the Hoses and Pipes group. It carries coolant or air between two points on the engine along a route shaped for its position. Volvo Penta publishes no fitment, dimensions or assembly detail against this number, so check it against the parts list for your own engine before ordering.

⚙️ Key Features

• Genuine Volvo Penta water pipe
• Hoses and Pipes group
• Rigid line within the engine's plumbing
• No fitment or dimensions published against this number — check it against the parts list for your engine

🔌 Function

Carries coolant or air between two points on the engine along a route shaped for its position.

⚠️ Common Signs of Failure

• Coolant loss with no obvious drip, or a weeping stain and crust of dried coolant at a joint or along the pipe
• Corroded or rust-stained pipe walls, pinholing, or a soft patch that gives under thumb pressure
• Overheating or erratic running temperature where a partly blocked or collapsed pipe is restricting flow
• Salt or scale build-up at the connections, or a joint that will no longer hold a seal however carefully it is refitted

🛠️ Service Notes

• Drain the system to below the level of the pipe before disconnecting it and catch what comes out — coolant and raw water both make a mess of a bilge
• Renew the O-rings, seals or gaskets at each joint rather than reusing them, and lubricate rubber seals with clean coolant or the lubricant the manual specifies, never with oil or grease
• Check the bore is clear and clean before fitting; scale, silt and debris carried over from the old pipe will lodge in the pump or heat exchanger
• Support the pipe on its original brackets and clips so the joints carry no strain, and keep it clear of hot surfaces and moving parts
• Refill, bleed, then run the engine and check every joint for weeping while it is warm and under pressure

📦 Condition

• Genuine Volvo Penta part
• Brand new
• Supplied in original or equivalent packaging